Aprilaire Air Duct Cleaning Nationwide

Aprilaire Air Duct Cleaning in Houston: What to Know First

Aprilaire air duct cleaning in Houston runs $850 to $1,450 for a full system on a typical 2,500-square-foot house, with the job usually finished in one visit. We work as an independent Aprilaire service provider, meaning your manufacturer warranty stays intact because we never bypass Aprilaire components, and our process is built around the filtration systems Aprilaire owners already trust. If you own an Aprilaire whole-home air purifier or a Space-Gard media filter cabinet, this page explains what you should know before anyone puts a brush in your ducts. Call us at (713) 936-5800 for a written quote before we touch anything.

Call (713) 936-5800

How Aprilaire Products Fail – and How We Fix Them

Aprilaire builds good filtration, but the ductwork around it takes a beating in Houston’s humidity. Here are the failure patterns we see on Aprilaire-equipped homes, and what we do about them.

• Aprilaire Space-Gard 2200 media cabinets with collapsed filter tracks. The filter sits in a metal track that warps over years of Houston heat and humidity. When the track bends, unfiltered air bypasses the media entirely and pulls attic dust straight into the supply ducts. We straighten or replace the track during the duct cleaning, so the new filter actually seals. Most homeowners never see this because the cabinet door covers it.
• Aprilaire 5000 electronic air cleaner cells caked with baked-on fine dust. The 5000 series uses charged collection plates, and in Houston’s humidity they collect a paste-like film that hardens when the AC runs hard in summer. Once that happens the plates lose charge and stop catching anything. We remove and clean the cells as part of the job, then run the system under negative pressure so the loosened debris leaves through our HEPA-filtered vacuum, not back into your house.
• Return ducts pulling attic heat through Aprilaire filter slots that don’t seal. Many Houston homes have Aprilaire filter bases mounted at the return plenum, and the access door gasket rots fast in our climate. Air bypasses the filter and drags insulation fibers into the return line. We replace the gasket and clean the entire return run back to the air handler.
• Supply ducts downstream of Aprilaire humidifiers with mineral scale buildup. Aprilaire humidifiers tap into the water line, and Houston’s hard water leaves calcium scale in the duct just past the humidifier. That scale catches dust and grows into a crust that restricts airflow to far rooms. We remove the scale during cleaning and advise on the right pad replacement schedule so it doesn’t return in six months.
• Aprilaire model 1610 thermostats reading false-high due to dust on the sensor. This one is simple but common. When ducts shed fine dust, it settles on the Aprilaire thermostat sensor and the unit thinks the house is warmer than it is, short-cycling the AC. We wipe the sensor as part of every duct cleaning and show you how to check it between service calls.

Our Aprilaire Air Duct Cleaning Process

Every Aprilaire duct cleaning job in Houston follows the same sequence. No shortcuts, no surprises at the door.

1. 1
   Walkthrough and inspection. We map the full duct layout, check every Aprilaire filter cabinet, humidifier, and purge grille, and confirm the price in writing before any equipment leaves the van.
2. 2
   Seal off the system. We isolate supply and return runs with foam blocks and connect our Nikro negative-air machine to create pull on the entire duct network. This keeps loose dust from entering living space during the cleaning.
3. 3
   Rotobrush agitation. A rotary brush runs through every supply and return run, breaking the dust film and compacted debris from the duct walls. In Houston, that debris is often a mix of attic humidity clumping, construction dust, and years of pet dander that attached to the moisture.
4. 4
   Component cleaning. Every Aprilaire air cleaner cell, filter track, humidifier pad housing, and grill gets cleaned to bare metal or plastic, then reassembled and checked for seal. We use OEM Aprilaire replacement pads and filters on request, or a quality aftermarket equivalent if you prefer.
5. 5
   Video verification. Before-and-after footage runs through the ducts so you see exactly what was removed. No one gets asked to sign off blind.
6. 6
   Pressure and airflow test. We check static pressure at the air handler and airflow at the registers. The job isn’t done until the system breathes like it should.

What Aprilaire Air Duct Cleaning Costs in Houston

These are the ranges for Aprilaire-equipped homes, written the same way we quote them: a flat price per system, agreed to before we start, with no per-vent add-ons.

• Single system, up to 10 vents (typical 1,500 – 2,000 sq ft home): $450 – $650
• Full system, 10 – 16 vents (typical 2,000 – 2,800 sq ft home): $600 – $850
• Full system, 16 – 22 vents (typical 2,800 – 3,800 sq ft home): $850 – $1,150
• Large or two-story systems, 22+ vents or dual air handlers: $1,150 – $1,450
• Aprilaire 5000 electronic cell deep clean (add-on during duct cleaning): $120 – $180
• Aprilaire Space-Gard track repair or replacement (add-on): $60 – $140

What moves the price: duct length, number of vents, accessibility of the air handler, and whether the Aprilaire components need cleaning or repair along with the ducts. Crawl space or attic hatch access adds time, and we price that honestly up front. Call (713) 936-5800 and we’ll give you a written quote that does not change when the technician arrives.

Why Houston Homeowners Call Hollis Air Duct Houston for Aprilaire Work

Most duct cleaners in Houston will happily clean any duct system. Very few understand what an Aprilaire filter cabinet, humidifier, or electronic air cleaner means for how the job gets done. Our technicians work on Aprilaire-equipped homes every week, and we make decisions that protect your warranty and your air quality at the same time. The 365-Day Done Right Promise covers every Aprilaire job in writing: if the work fails within a year, we return at no charge, including the second visit. Period. We also service homes running Lennox, Trane, and Carrier, so if you have a multi-brand system or a friend with a different setup, the same standard applies. Written price before work starts. Uniformed, background-checked technicians. A live person answers the phone at (713) 936-5800, day or night. That’s The Garrison Standard, and it’s how Roy Castellanos runs every job in Houston.

FAQs